Ford Explorer: Roof Opening Panel / Removal and Installation - Roof Opening Panel Fixed Glass

Ford Explorer 2020-2024 Service Manual / Body and Paint / Body and Paint / Roof Opening Panel / Removal and Installation - Roof Opening Panel Fixed Glass

Removal

NOTE: Removal steps in this procedure may contain installation details.

  1. Remove the roof opening panel frame.
    Refer to: Roof Opening Panel Frame (501-17 Roof Opening Panel, Removal and Installation).

  1. Remove the roof opening panel fixed glass.
    1. Remove the bolts.
      Torque: 35 lb.in (4 Nm)
    1. Carefully lift the frame assembly to remove the roof opening panel fixed glass.

Installation

  1. To install, reverse the removal procedure.

    Removal and Installation - Roof Opening Panel Control Switch

    Removal The roof opening panel switch is replaced as an assembly with the overhead console. Refer to: Overhead Console (501-12 Instrument Panel and Console, Removal and Installation)...

    Removal and Installation - Roof Opening Panel Frame

    Removal NOTE: Removal steps in this procedure may contain installation details. If replacing the roof opening panel frame, remove the air deflector...

    Other information:

    Ford Explorer 2020-2024 Service Manual: Removal and Installation - Audio Unit Antenna Cable


    Special Tool(s) / General Equipment Interior Trim Remover Removal Instrument panel AM/FM coaxial cable Remove the floor console. Refer to: Floor Console (501-12 Instrument Panel and Console, Removal and Installation). Remove the RH front scuff plate trim panel...

    Ford Explorer 2020-2024 Service Manual: General Procedures - Valve Guide Inner Diameter


    Check NOTE: Refer to the appropriate Section 303-01 for the specification. NOTE: Valve guides tend to wear in an hourglass pattern. The ball gauge can be inserted into the combustion chamber side of the valve guide, if necessary. Use a ball gauge to determine the inside diameter of the valve guides in 2 directions at the top, middle and bottom of the valve guide...

    Categories

    Fastening the Seatbelts

    The front outboard and rear safety restraints in the vehicle are combination lap and shoulder belts.

    read more

     
    Copyright © 2024 www.foexplorer.com