Ford Explorer: Roof Opening Panel / Removal and Installation - Trough Assembly

Ford Explorer 2020-2024 Service Manual / Body and Paint / Body and Paint / Roof Opening Panel / Removal and Installation - Trough Assembly

Removal

NOTE: Removal steps in this procedure may contain installation details.

  1. Remove the roof opening panel glass.
    Refer to: Roof Opening Panel Glass (501-17 Roof Opening Panel, Removal and Installation).
  1. Remove the roof opening panel fixed glass.
    Refer to: Roof Opening Panel Fixed Glass (501-17 Roof Opening Panel, Removal and Installation).
  1. NOTE: Note the spring orientation during removal. If installing a new drain trough, the spring will need to be transferred to the new drain trough and placed in the same position during installation.


    Remove the trough assembly.
    1. Spread the trough retaining tabs on the guide.
    1. Lift the back of the trough to disconnect from the guides.

Installation

  1. To install, reverse the removal procedure.
  1. NOTE: Spring position before installing the trough.

    On both sides.
    If installing a new drain trough, the spring will need to be transferred to the new drain trough.
  1. On both sides.
    The tab on the trough must be positioned behind the tab on the bracket when installing.

    Removal and Installation - Roof Opening Panel Shield

    Special Tool(s) / General Equipment Interior Trim Remover Removal NOTE: Removal steps in this procedure may contain installation details...

    Bumpers

    ..

    Other information:

    Ford Explorer 2020-2024 Service Manual: General Procedures - Transmission Park by Wire Manual Release


    Activation NOTE: If the vehicle has a discharged battery, an external power source is required. Apply the parking brake. Open the console door Remove the console mat. NOTE: Use a screwdriver no longer than 120 mm (4...

    Ford Explorer 2020-2024 Service Manual: Removal and Installation - Front Seat Cushion Blower Motor


    Removal Raise the front seat to its highest point of travel. Remove the front seat cushion blower motor. Disconnect the electrical connector. Rotate the blower motor 45 degrees clockwise. Installation To install, reverse the removal procedure...

    Categories

    Intelligent Access Key

    Note: You may not be able to shift out of park (P) unless the intelligent access key is inside your vehicle.

    read more

     
    Copyright © 2024 www.foexplorer.com