Ford Explorer: Engine - 2.3L EcoBoost (201kW/273PS) / Disassembly and Assembly of Subassemblies - Piston

Ford Explorer 2020-2026 Service Manual / Powertrain / Engine / Engine - 2.3L EcoBoost (201kW/273PS) / Disassembly and Assembly of Subassemblies - Piston

DISASSEMBLY

NOTE: If the piston and connecting rod are to be reinstalled, they must be assembled in the same orientation. Mark the piston orientation to the connecting rod reassembly.

  1. Remove the piston rings and discard.
    • Remove the piston pin retainers and discard.
    • Remove the piston pin.
  1. NOTE: If the piston and connecting rod are to be reinstalled, they must be assembled in the same orientation. Mark the piston orientation to the connecting rod for reassembly.

    • Remove the piston from the connecting rod.
    • Inspect the piston.
      Refer to: Piston Inspection (303-00 Engine System - General Information, General Procedures).

ASSEMBLY

  1. NOTE: Align the piston-to-connecting rod orientation marks made during disassembly.

    Install the piston to the connecting rod.
  1. Lubricate with clean engine oil and install the piston pin.
  1. Install the piston pin retainers.
  1. Lubricate with clean engine oil and install the piston rings.
  1. NOTE: Align the piston rings on the piston.

    NOTE: Arrow indicates front of engine.

    1. Upper oil control segment ring gap location.
    1. Oil control spacer gap location.
    1. Lower oil control segment ring gap location.

    Disassembly and Assembly of Subassemblies - Cylinder Head

    Special Tool(s) / General Equipment 303-1249Valve Spring CompressorTKIT-2006UF-FLMTKIT-2006UF-ROW 303-1567Sizer, Teflon SealTKIT-2010C-FLM 303-300 (T87C-6565-A) Set, Valve Sprin..

    Assembly - Engine

    Special Tool(s) / General Equipment 100-002 (TOOL-4201-C) Holding Fixture with Dial Indicator Gauge 205-153 (T80T-4000-W) Handle 303-050 (T70P-6000) Lifting Bracket, Engine ..

    Other information:

    Ford Explorer 2020-2026 Service Manual: Removal and Installation - Axle Housing Bushing


    Special Tool(s) / General Equipment 205-1066Installer, Bushing Flat Headed Screw Driver Removal NOTE: Only worn or damaged bushings need to be replaced. Remove the rear axle assembly. Refer to: Axle Assembly (205-02 Rear Drive Axle/Differential, Removal and Installation)...

    Ford Explorer 2020-2026 Service Manual: Removal and Installation - Auxiliary Battery


    Removal NOTE: Removal steps in this procedure may contain installation details. Disconnect the batteries. Refer to: Battery Disconnect and Connect (414-01 Battery, Mounting and Cables, General Procedures). Disconnect the vent hose from the auxiliary battery...

    Categories

    Child Safety Locks

    When these locks are set, you cannot open the rear doors from the inside.

    A child safety lock is on the rear edge of each rear door. You must set the child safety lock separately on each door.

    Left-Hand Side

    read more

     
    Copyright © 2026 www.foexplorer.com