Ford Explorer: Instrument Panel and Console / Removal and Installation - Floor Console

Ford Explorer 2020-2025 Service Manual / Body and Paint / Body and Paint / Instrument Panel and Console / Removal and Installation - Floor Console

Removal

All vehicles except Police

NOTE: Removal steps in this procedure may contain installation details.

  1. Remove the front seats.
    Refer to: Front Seat (501-10A Front Seats, Removal and Installation).
  1. Release the clips and remove the RH floor console side trim panel.
  1. Disconnect the RH floor console electrical connectors.
  1. Release the clips and remove the LH floor console side trim panel.
  1. Disconnect the LH floor console electrical connectors.

  1. Remove the bolts, position the console rearward to release the front clips and remove the front floor console
    1. Remove the front bolts.
      Torque: 28 lb.in (3.2 Nm)
    1. Remove the rear bolts.
      Torque: 48 lb.in (5.4 Nm)

Police vehicles


  1. Remove the police rear console extension plate.
    • Remove the bolts.
      Torque: 40 lb.in (4.5 Nm)
    • Remvoe the nuts.
      Torque: 40 lb.in (4.5 Nm)
  1. Remove the nuts and the front police floor console plate.
    Torque: 93 lb.in (10.5 Nm)

Installation

  1. To install, reverse the removal procedure.

    Removal and Installation - Auxiliary Power Point

    Special Tool(s) / General Equipment 501-194Remover, Power PointTKIT-2014D-ROW2TKIT-2014D-FL_ROW Removal Open the power point cover...

    Removal and Installation - Glove Compartment

    Removal NOTE: Removal steps in this procedure may contain installation details. Push the stop tabs inwards and fully lower the glove compartment...

    Other information:

    Ford Explorer 2020-2025 Service Manual: Diagnosis and Testing - Wipers and Washers


    Diagnostic Trouble Code (DTC) Chart Diagnostics in this manual assume a certain skill level and knowledge of Ford-specific diagnostic practices. REFER to: Diagnostic Methods (100-00 General Information, Description and Operation).   Diagnostic Trouble Code Chart Module   DTC Description Action   BCM B130F:1..

    Ford Explorer 2020-2025 Owners Manual: Changing the Engine Air Filter - 3.3L


    WARNING: To reduce the risk of vehicle damage and personal burn injuries, do not start your engine with the air cleaner removed and do not remove it while the engine is running. Note: Failure to use the correct air filter element may result in severe engine damage...

    Categories

    Child Safety Locks

    When these locks are set, you cannot open the rear doors from the inside.

    A child safety lock is on the rear edge of each rear door. You must set the child safety lock separately on each door.

    Left-Hand Side

    read more

     
    Copyright © 2025 www.foexplorer.com